![background image](/i/kawasaki/160295/kawasaki-vn1600-classic-2003/h/kawasaki-vn1600-classic-2003-567.png)
APPENDIX 17-25
Cable, Wire, and Hose Routing
F: Front
1. Main Harness: Run it into the headlight
body and inside the brake hose [3].
2. Throttle Cables
3. Front Brake Hose
4. Rear Brake Light Switch Connector (BR,
BL leads, under the connector [5])
5. Radiator Fan Connector (BK/Y, Y/W,
BR/W lead, over the connector [4])
6. Plastic Snap-on Clamp (radiator fan and
rear brake light switch leads)
7. Inlet Air Pressure Sensor Connector
8. Plastic Snap-on Clamp (rear brake light
switch lead)
9. Ignition Coil Primary Lead Connectors
(for rear cylinder)
10. Injector #2 Connector (rear)
11. Water Temperature Sensor Connector
(thermostat housing)
12. Throttle Sensor Connector
13. Clutch Hose
14. Horn Lead
15. Choke Knob
16. Frame Ground Terminal
17. Ignition Coil Primary Lead Connectors
(for front cylinders)
18. Atmospheric Pressure Sensor Connector
19. Harness Clamp: Fit it into the frame pipe.
20. Throttle Cables
21. Injector #2 Connector (rear)
22. Injector #1 Connector (front)
23. Main Harness Bracket
24. Fit the straps into the frame pipe
25. White Tape for Identification
26. Battery (–) Lead from engine ground lead
27. Oil Pressure Light Delay Unit
28. ECU Main Relay
29. Turn Signal Control Unit
30. Starter Relay
31. Batter (+) Terminal
32. White Tape: Align it with the grommet
33. Starter Motor Lead
34. Battery (–) Lead Connector
35. Fuel Pump Connector
36. ECU Connector
37. ECU Main Fuse
38. Fuel Level Sensor Connector
39. Plastic Snap-on Clamp
40. Battery Holder: Fit [35], [37], [38] and [39]
into the holder.
41. Accessory Lead Connectors (female)
42. Rear Turn Signal/Taillight Lead Connec-
tor
43. Self-Diagnossis Terminal
44. Put these connectors into the alternator
outer cover.
45. Front Turn Signal Light Leads: Connect
them in the headlight body.
46. Run the leads [45] into the holes of the
bracket.
47. Left Handlebar Switch Leads: Connect
them in the headlight body.
48. Straps
49. Right Handlebar Switch Leads